Deposition of Ga2O3 thin films by liquid metal target sputtering
This paper reports on the deposition of amorphous and crystalline thin films of Ga2O3 by reactive pulsed direct current magnetron sputtering from a liquid gallium target onto fused (f-) quartz and c plane (c-) sapphire substrates, where the temperature of the substrate is varied from room temperature (RT) to 800°C. The deposition rate (up to 37 nm/min at RT on f-quartz and 5 nm/min at 800°C on c-sapphire) is two to five times higher than the data given in the literature for radio frequency sputtering. Deposited onto unheated substrates, the films are X-ray amorphous. Well-defined X-ray diffraction peaks of \b{eta}-Ga2O3 start to appear at a substrate temperature of 500°C. Films grown on c-sapphire at temperatures above 600°C are epitaxial. However, the high rocking curve full width at half maximum values of {\approx} 2.4-2.5° are indicative of the presence of defects. A dense and void-free microstructure is observed in electron microscopy images. Composition analysis show stoichiometry close to Ga2O3 and no traces of impurities. The optical properties of low absorptance (<1%) in the visible range and an optical band gap of approximately 5 eV are consistent with the data in the literature for Ga2O3 films produced by other deposition methods.